Wagner Power Painter Plus and Wagner Project Sprayer - Review
Wagner SprayTech has recently released a number of hand held paint sprayers and they were nice enough to send two of them our way for review purposes. That was months ago. Since that time, we've used every available excuse to not get around to reviewing the items...but they're going to be really messy....it's going to take a long time to figure out how to use them....there's going to be paint everywhere....it'll take three hours just to clean everything...and so on. About a week ago, we'd had enough procrastinating and carved out an afternoon to investigate the Power Painter Plus and the Project Sprayer. And at this point, we now feel we owe Wagner a huge apology for thinking that their little sprayers were going to be a hassle. They weren't. In fact they're pretty easy to deal with.
Both of the items have the same look and feel. Sort of like a screw gun with a big plastic udder hanging off it. The basics of operating them includes filling up the canister and, after plugging the sprayer in, pulling the trigger. That's really all there is to it. You can toggle between a vertical spray or a horizontal one by moving the nozzle to the appropriate position.
Using the sprayers takes a little getting used to, but not as much as we had thought. We're not used to sprayers, so if you're in the same boat, we suggest getting a sheet of 1/4" ply wood and painting it until you feel confident with the sprayer. After about 20 minutes of this, we got good at laying down a nice, even spray.
Of the two models, the Power Painter Plus is the more feature-laden and thus has more versatility. In addition to the plastic canister, the Power Painter Plus also comes with a hose, which allows you to siphon paint right out of a can. This is good for a few reasons. One, you don't have to worry about continually refilling the canister during larger jobs and two, you're now free to tilt the sprayer up at something. While using the canister, from time to time, we would tilt the gun to paint the underside of something which would cause the paint level to go below the siphon and thus leave the gun literally spitting out paint, which was not good for the paint job. To ensure that this doesn't happen using the hose method, Wagner has supplied a little clip that holds the hose in the paint can, so it stays in place. There is also a backpack assembly, sold separately, so ladder work is possible with a larger volume of paint.
It's worth noting that the Power Painter Plus also comes with a carrying case.
Setting up and using the guns is easy enough, but how about clean-up, the bane of any painting project? It's actually not too bad. The process involves pretty much taking the tool apart and making sure that every little piece gets 100% cleaned. The Power Painter Plus comes with a special canister cover that allows you to place all the small pieces in the canister and then connect a hose up to it in order to cycle water through. We tried it out, but discovered that two 5-gallon buckets were just as good for us. We tested the sprayers out with a latex paint, so clean-up was all done with soap and water. Oil paint, on the other hand, involves thinner which would likely complicate matters to the point where we would probably end up throwing everything away at the end of day one.
So, in the end, are they worth it? Well, it depends on what you're painting and how much patience you have to handle things like the spraying learning curve and the clean-up process. If you're going to be doing some interior walls, you're insane to consider using a sprayer (check out Wagner's TurboRoll instead - our review here). But if you need to deal with things like shutters, lawn furniture, or a picket fence, then definitely consider one of these sprayers.
The Project Sprayer runs for $60 while the Power Painter plus will set you back $85.
Project Sprayer at Amazon.com
Power Painter Plus at Amazon.com
Read More in: All Reviews | Painting
Share this Article with others:
Came straight to this page? Visit Tool Snob for all the latest news.
Posted by Doug Mahoney at August 24, 2009 4:20 AM